Product ID:RED TRAFFIC LINE PAINT, 1072
MSDS Date:01/01/1992
FSC:8010
NIIN:00N038778
MSDS Number: BRHLR

FARWEST PAINT MANUFACTURING CO

4522 SOUTH 133 ST
TUKWILA, WA 98168
US

Emergency Phone: 206-941-1619

Info Phone: 206-244-8844

Cage: 2F266

FARWEST PAINT MANUFACTURING CO

TUKWILA, WA 98168 US

Telephone: 206-244-8844

Cage: 6F266

NAPHTHA, LIGHT ALIPHATIC (PETROLEUM); (MINERAL SPIRITS 250)

CAS: 64742-89-8

Fraction By Weight: 34%

OSHA PEL N/K

ACGIH TLV: N/K

LEAD CHROMATE MOLYBDATE; (MOLYBDATE ORANGE PIGMENT)

CAS: 12656-85-8

RTECS: QA4660000

Fraction By Weight: 2.45%

OSHA PEL 5 MG/M3

ACGIH TLV: 5 MG/M3

LEAD (SARA III)

CAS: 7439-92-1

RTECS: OF7525000

Fraction By Weight: 56.7%

OSHA PEL 0.05 MG/M3

ACGIH TLV: 0.15 MG/M3 DUST

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

CHROMATE

Fraction By Weight: 19.6%

OSHA PEL N/K

ACGIH TLV: N/K

LIGROINE; (MINERAL SPIRITS 350)

CAS: 8032-32-4

RTECS: OI6180000

Fraction By Weight: 2.8%

OSHA PEL 300 PPM;400 PPM STEL

ACGIH TLV: 300 PPM

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:NOTE:LEAD (7439-92-1) APPEARS ON NAVY
LIST OF OCCUP REPRO HAZS. SEEK CONSULTATION FROM APPROP HLTH PROFS
CONCERNING LATEST HAZ LIST INFO & SAFE HNDLG & EXPOS RECS .
SKIN:MATL MAY CAUSE IRRIT, SE NSIT OR DEFAT UPON PRLNG/RPTD
CONTACT. INHAL:EXCESS EXPOS TO VAPS/SPRAY MISTS CAN RESULT IN HDCH,
DIZZ,(EFTS OF OVEREXP)
Explanation of Carcinogenicity:LEAD:GROUP 2B(IARC V-7,230,87).MOLYBDATE
ORANGE;GROUP 1 (IARC V-49,49,90)
Effects of Overexposure:HLTH HAZ:NAUSEA & LOSS OF CONSCIOUSNESS. SOME
REPORTS HAVE ASSOC RPTD & PRLNG OCCUP OVEREXP TO SOLVS W/PERM BRAIN
& NERV SYS DMG. EYES:MATL MAY BE IRRITANT. INGEST:ASPIRATION OF
MATL INTO LUNGS CAN CA USE CHEMICAL PNEUMONITIS WHICH CAN BE FATAL.
Medical Cond Aggravated by Exposure:NONE, WHEN USED I/A/W SAFE HANDLING
INSTRUCTIONS.

First Aid:SKIN:PROMPTLY WASH W/SOAP & WATER. REMOVE & WASH ANY CONTAM
CLOTHING BEFORE REUSE. EYES:FLUSH W/LARGE QTYS OF WATER FOR AT
LEAST 15 MINUTES & SEEK MEDICAL ATTN. INGEST:DO NOT INDUCE
VOMITING, KEEP PER SON WARM, QUIET & GET MEDICAL ATTENTION.
INHAL:REMOVE VICTIM TO FRESH AIR IMMEDIATELY. IF RESPIRATORY
SYMPTOMS DEVELOP, SEEK MEDICAL ATTENTION AT ONCE.

Flash Point Method:TCC
Flash Point:52.0F,11.1C
Lower Limits:0.7%
Extinguishing Media:FOAM, CO*2, DRY CHEM, WATER FOG. USE THESE/ANY
CLASS B EXTING AGENT. WATER MAY BE UNSUITABLE AS EXTING MEDIUM,
(SUPDAT)
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . EVACUATE AREA OF UNPROTECTED PERSONNEL.
Unusual Fire/Explosion Hazard:VAPORS MAY FORM EXPLO MIXT IN AIR & MAY
BE IGNITED BY SPKS, PILOT LIGHTS, ETC. CLSD CNTNRS MAY RUPTURE WHEN
EXPOSED TO EXTREME HEAT.

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENT AREA.
ABSORB SPILL W/ABSORB MATL SUCH AS SAWDUST, VERMICULITE/SAND &
PLACE MATL INTO CLSD CNTNR. IF LG SPILL, DIKE AREA TO PVNT MATL
FROM ENTERING WATER SYS/SEWERS . WEAR PROT EQUIP DURING CLEANUP.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:AVOID PRLNG/RPTD INHAL OF HEATED
VAPS/SPRAY MISTS. KEEP AWAY FROM HEAT/OPEN FLAME. MATL MAY CAUSE
SENSIT. DO NOT GET IN EYES, ON SKIN OR ON CLTHG.
Other Precautions:DO NOT ALLOW CONTAMINATED CLOTHING TO CONTACT SKIN.
DO NOT WELD ON FULL/EMPTY CONTAINERS. KEEP CONTAINERS CLOSED, WHEN
NOT IN USE, & PROPERLY LABELED. KEEP OUT OF REACH OF CHILDREN.

Respiratory Protection:A NIOSH/MSHA APPROVED CANISTER-TYPE RESPIRATOR
MUST BE WORN TO PREVENT INHALATION OF VAPORS OR SPRAY MISTS WHEN
TLV OR PEL IS EXCEEDED.
Ventilation:GEN VENT IS REQD DURING NORMAL USE. LOC VENT MAY BE REQD
DURING CERTAIN OPERATIONS TO KEEP EXPOS LEVEL BELOW (SUPDAT)
Protective Gloves:CHEM RESIST NITRILE/NEOPRENE/RUB GLOVES.
Eye Protection:CHEM WORK GOGG W/FULL LGTH FCSHLD
Other Protective Equipment:WEAR PROTECTIVE CLOTHING TO PREVENT SKIN
CONTACT. EYE WASH STATION & SAFETY SHOWER SHOULD BE AVAILABLE.
Work Hygienic Practices:WASH HANDS BEFORE EATING OR SMOKING.
Supplemental Safety and Health
EXTING MEDIA:BUT HELPFUL IN KEEPING ADJACENT CNTNRS COOL. WASTE DISP
METH:I/A/W LOC, STATE & FED AGENCYS. GROUND HNDLG EQUIP TO PVNT
SPKS. FOR FURTHER INFO CONT YOUR STATE/LOC WASTE AGENCY/U.S. EPA'S
RCRA HOTLINE (1-800-424-9346 OR 1-202-382-3000). VENT:LIMITS LISTED
IN INGREDIENTS SECTION OF THIS MSDS.

Boiling Pt:B.P. Text:>205F,>96C
Vapor Pres:53 @ 20C
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NIL
Appearance and Odor:RED LIQUID.
Percent Volatiles by Volume:57

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT W/STRONG OXIDANTS, ACIDS, BASES & EPOXY HARDENERS UNDER
UNCONTROLLED CONDITIONS.
Stability Condition to Avoid:HEAT, SPARKS & OPEN FLAMES. IF PROD
CONTAINS ALUMINUM, MOISTURE IN CLSD CNTNRS WILL GENERATE HYDROGEN
GAS.
Hazardous Decomposition Products:INCOMPLETE COMBUSTION CAN YIELD CARBON
MONOXIDE & TOXIC VAPORS.

Waste Disposal Methods:IF DISCARDED, THIS MATL & CNTNRS SHLD BE TREATED
AS HAZ WASTES BASED ON CHARACT OF IGNITABILITY AS DEFINED UNDER FED
RCRA REGS (40 CFR 261). DISP OF THIS MATL/ITS CNTNR REQS COMPLIANCE
W/APPLIC LABELI NG, PACKAGING & RECORDKEEPING STDS. DISP (SUPDAT)

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.